Long term monitoring and evaluation of the excavation damaged zone induced around the wall of the shaft applying optical fiber sensor (Cooperative research)

Hata, Koji*; Niunoya, Sumio*; Uyama, Masao*; Nakaoka, Kenichi*; Fukaya, Masaaki*; Aoyagi, Kazuhei; Sakurai, Akitaka; Tanai, Kenji

JAEA-Research 2020-010, 142 Pages, 2020/11

JAEA-Research-2020-010.pdf:13.74MB
JAEA-Research-2020-010-appendix(DVD-ROM).zip:149.9MB

In the geological disposal study of high-level radioactive waste, it is suggested that the excavation damaged zone (EDZ) which is created around a tunnel by the excavation will be possible to be one of the critical path of radionuclides. Especially, the progress of cracks in and around the EDZ with time affects the safety assessment of geological disposal and it is important to understand the hydraulic change due to the progress of cracks in and around EDZ. In this collaborative research, monitoring tools made by Obayashi Corporation were installed at a total of 9 locations in the three boreholes near the depth of 370 m of East Shaft at the Horonobe Underground Research Laboratory constructed in the Neogene sedimentary rock. The monitoring tool consists of one set of "optical AE sensor" for measuring of the mechanical rock mass behavior and "optical pore water pressure sensor and optical temperature sensor" for measuring of groundwater behavior. This tool was made for the purpose of selecting and analyzing of AE signal waveforms due to rock fracture during and after excavation of the target deep shaft. As a result of analyzing various measurement data including AE signal waveforms, it is able to understand the information on short-term or long-term progress of cracks in and around EDZ during and after excavation in the deep shaft. In the future, it will be possible to carry out a study that contributes to the long-term stability evaluation of EDZ in sedimentary rocks in the deep part of the Horonobe Underground Research Laboratory by evaluation based on these analytical data.

Visualization of fractures in an Excavation Damaged Zone in the Horonobe Underground Research Laboratory (Joint research)

Aoyagi, Kazuhei; Chen, Y.*; Sakurai, Akitaka; Ishii, Eiichi; Ishida, Tsuyoshi*

JAEA-Research 2017-014, 49 Pages, 2018/01

JAEA-Research-2017-014.pdf:16.29MB

In this research, we performed the resin injection experiment at the 350 m gallery of the Horonobe Underground Research Laboratory in order to identify the three dimensional distribution of fractures induced around the gallery owing to excavation. To this end, the low viscosity resin mixed with a fluorescent substance was developed and applied to the in situ resin injection experiment. As a result, the resin was successfully penetrated into the fractures around the gallery without disturbing their situation and then fixed within them. After the experiment, the rock cores around the injection borehole were drilled for the observation. The observation under ultraviolet light revealed that the extent of the development of fractures was about 0.9 m into the borehole wall. In addition, the aperture of the fractures distributed within 0.3 m from the gallery wall was ranged 1 to 2 mm, and that distributed from 0.3 to 0.9 m was less than 1 mm. On the other hand, in the borehole televiewer (BTV) survey, only one fracture within 0.2 m from the wall could be detected owing to the resolution of the survey system. Thus, it is expected that the BTV survey underestimate the extent of the development of fractures.

Confirmation of the applicability of low alkaline cement-based material in the Horonobe Underground Research Laboratory

Nakayama, Masashi; Niunoya, Sumio*; Minamide, Masashi*

Genshiryoku Bakkuendo Kenkyu (CD-ROM), 23(1), p.25 - 30, 2016/06

https://doi.org/10.3327/jnuce.23.1_25

In Japan, any high-level radioactive waste repository is to be constructed at over 300m depth below surface. Tunnel support is used for safety during the construction and operation, and shotcrete and concrete lining are used as the tunnel support. Concrete is a composite material comprised of aggregate, cement and various additives. Low alkaline cement has been developed for the long term stability of the barrier systems whose performance could be negatively affected by highly alkaline conditions arising due to cement used in a repository. Japan Atomic Energy Agency (JAEA) has developed a low alkaline cement, named as HFSC (Highly fly-ash contained silicafume cement), containing over 60wt% of silica-fume (SF) and coal ash (FA). JAEA is presently constructing an underground research laboratory (URL) at Horonobe for research and development in the geosciences and repository engineering technology. HFSC was used experimentally as the shotcrete material in construction of part of the 350m deep gallery in Horonobe URL in 2013. The objective of this experiment was to assess the performance of HFSC shotcrete in terms of mechanics, workability, durability, and so on. HFSC used in this experiment is composed of 40wt% OPC (Ordinary Portland Cement), 20wt% SF, and 40wt% FA. This composition was determined based on mechanical testing of various mixes of the above components. Because of the low OPC content, the strength of HFSC tends to be lower than that of OPC in normal concrete. The total length of tunnel constructed using HFSC shotcrete is about 112m at 350m deep drift. The workability of HFSC shotcrete was confirmed by this experimental construction. In this report, we present detailed results of the in-situ construction test.